Slab Quality and Environmental Degradation with The Addition of Additives and Coagulant

Authors

  • Afriyani Zulyanti
  • Amin Rejo
  • Farry Apriliano Haskari
  • Afrizal Vachlepi

DOI:

https://doi.org/10.22135/sje.2017.2.2.35-39

Abstract

Abstract : This research used ammonium chloride at doses of 0%, 0.15%, 0.30% and 0.45% with 0% dose, 0.15%, 0.30% and 0.45% while formic acid and liquid smoke coagulants.  The objective of this research is to determine the effects of the addition of additives (NH4Cl) and the type of coagulants on the quality slab degradation. The observed parameters were the value of dry rubber content (%), initial plasticity (Po), plasticity retention index (PRI), ash content (%), volatile matter (%) and Mooney viscosity. The results showed that doses ammonium chloride and coagulants affected to the value of dry rubber content (%), initial plasticity (Po), plasticity retention index (PRI), ash content (%), volatile matter (%) and Mooney viscosity. The treatment dose 0.45% ammonium chloride with coagulant has the best combination treatment reason it produced slab with dry rubber content 46.517%, initial plasticity 45, plasticity retention index 94, ash content 0.278%, volatile matter 0.604% and Mooney viscosity 72.

Keywords: Ammonium chloride, coagulants and slab.

 

Abstrak (Indonesian) : Penelitian ini menggunakan amonium klorida dengan dosis 0%, 0,15%, 0,30% dan 0,45% sedangkan jenis koagulan asam format dan asap cair.  Penelitian ini dilakukan untuk mengetahui pengaruh penambahan zat aditif (NH4Cl) dan jenis koagulan terhadap degradasi mutu sleb.  Parameter yang diamati adalah kadar karet kering (%), plastisitas awal (Po), indeks retensi plastisitas (PRI), kadar abu (%), kadar zat menguap (%), viskositas Mooney. Hasil penelitian menunjukkan bahwa penambahan dosis amonium klorida dan jenis koagulan berpengaruh nyata terhadap kadar karet kering (%), plastisitas awal (Po), indeks retensi plastisitas (PRI), kadar abu (%), kadar zat menguap (%), viskositas Mooney. Perlakuan dosis amonium klorida 0,45% dengan koagulan asam format merupakan perlakuan terbaik menghasilkan kadar karet kering 46,517%, plastisitas awal 45, indeks retensi plastisitas 94, kadar abu 0,278% , kadar zat menguap 0,604% dan viskositas Mooney 72.

Kata Kunci: Amonium klorida, koagulan dan sleb.

Downloads

Published

05/30/2017

Issue

Vol. 2 No. 2 (2017): Water As A Vital Resource for Life

Section

Articles

License

The initial copyright of a paper is held by the authors (or their employer, in some instances). When publishing that paper the copyright may continue to be held by the author, or can be licensed or transferred to the publisher.

DOAJ recommends that journals allow authors to retain the copyright of their papers without restrictions. Authors will then grant the publisher the right of first publication, and other non-exclusive publishing rights.

Even when the author retains copyright, restrictions may sometimes be imposed by the publisher:

  • The publisher requires exclusive publishing rights. This means that the author no longer holds copyright without restrictions.
  • The publisher requires a transfer or exclusive license of commercial rights. This means the author no longer holds copyright without restrictions.

Submission of a manuscript implies that the submitted work has not previously been published (except as part of a thesis, report, or abstract); that it is not currently under consideration for publication elsewhere; and that its publication has been approved by all co-authors.

We need publishing rights from you in order to publish and make available an article. As a result, we require authors who publish in Sriwijaya journal of Environment to sign an author contract, which grants us the necessary publishing rights. This will occur after your manuscript has been peer-reviewed, accepted, and moved into production. Our Production team will then send you an email with all of the details. https://creativecommons.org/licenses/by-nc-sa/4.0/